international journals on concrete fine aggregate replaced with quarry dust

  • Partial Replacement of Fine Aggregates with Quarry Dust

    International Journal of Engineering Trends and Applications (IJETA) – Volume 5 Issue 3, MayJun 2018 ISSN: 23939516 Page 57 Partial Replacement of Fine Aggregates with Quarry Dust and Marble Powder in Concrete

  • Use of Quarry Dust to Replace Sand in Concrete – An

    International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 1 ISSN 22503153 Use of Quarry Dust to Replace Sand in Concrete –

  • Studies on Quarry Dust as Partial Replacement of Fine

    to use Quarry dust to replace the fine aggregates in concrete Following are some of the conclusions drawn from the results of this investigation: 1 Quarry dust can be used as a finer material which can reduce the voids in concrete 2 Up to 20% replacement of fine aggregates by quarry dust, the results obtained are satisfactory 3

  • High performance concrete using quarry dust as fine aggregate

    ABSTRACT² This paper describes the experimental study of HighPerformance concrete with quarry dust as fine aggregate in addition of steel fibre To overcome the difficulties due to excessive sand mining, quarry dust was used as fine aggregate Quarry dust is the fine

    Author: V Priyadharshini, A Krishnamoorthi
  • Partial Replacement of Sand by Quarry Dust in Concrete

    investigated the partial replacement of sand with quarry dust Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25) The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties

    文件大小: 288KB
  • Use of Quarry Dust to Replace Sand in Concrete – An

    International Journal of Scientific and Research Publications, Volume 3, Issue 12, December 2013 1 ISSN 22503153 Use of Quarry Dust to Replace Sand in Concrete – An

  • USE OF QUARRY DUST IN CONCRETE AS REPLACEMENT

    Quarry dust is produced from crusher unit and each crusher unit is produced nearly 22% to 27% of dust This dust is completely waste material for crusher unit but quarry dust is useful for construction work as sand If we mix quarry dust in sand then only 65% to 75% of sand replaced by quarry dust because strength of concrete is

  • Partial Replacement of Sand by Quarry Dust in Concrete

    investigated the partial replacement of sand with quarry dust Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25) The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties

  • International Journal of Science and Research (IJSR)

    An Experimental Investigation on Properties of Concrete by Partial Replacement of Cement with GGBS and Fine Aggregate with Quarry Dust Dr D V Prasada Rao, C S Mallikarjuna In the present study an investigation is made on properties of concrete by partial replacement of Cement with Ground Granulated Blast Furnace Slag (GGBS) and Fine

  • Experimental Study on Use of Quarry Dust GRD Journals

    aggregates In this experimental study an attempt will be made to find the effect of partial replacement of Fine aggregate by Quarry Dust and Cement by Fly ash The innovative use of Quarry Dust in concrete formulations as a fine aggregate replacement in the range of 0%, 15%, 30% 45% by weight for M40 grade cement (PPC)

  • [PDF] Utilization of Quarry Dust in Cement Concrete Paver

    “Strength and durability properties of concrete containing quarry rock dust as fine aggregate” Natural river sand, if replaced by hundred percent Quarry Rock Dust from quarries, may sometimes give equal or better than the reference concrete made with Natural Sand, in

  • (PDF) EXPERIMENTAL STUDY ON REPLACEMENT OF FINE AGGREGATE

    concrete”, international Journal of the same quality which can replace river sand in concrete production 50% of fine aggregate with quarry dust, concrete of maximum compressive

  • PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

    corrosion resistance behavior of inhibitors in concrete containing quarry dust as fine aggregate,” Journal of Engineering and Applied Sciences, vol 6, no 11, pp 124–135, 2011 [12] R P Nanda, A K Das, and N Moharana, “Stone crusher dust as a fine aggregate in concrete for paving

  • EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

    to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete 12 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete The introduction of quarry dust for mixing is limited due to its high fineness

  • (PDF) REPLACEMENT OF FINE AGGREGATE WITH SAWDUST

    This experimental study is aimed to create a concrete mixture consisting of sawdust which replaces the fine aggregate It is also used to analyze the effect of sawdust concrete in terms of

  • Introduction to QuarryDust as Partial Replacement

    May 19, 2020  quarry dust as fine aggregate: effect on compressive strength , durability and workability of concrete The experimental study done by R Chandana Sukesh, Katakam Bala Krishna, PSri Lakshmi Sai Teja, SKanakambara Rao[6] in which replacement of the sand with quarry dust shows an improvement in the compressive strength of the concrete

  • Replacement of Fine Aggregate by using Recyclable

    Various industrial waste materials like quarry dust, glass powder, ceramic dust and coal dust are used as partial replacement of fine aggregate and assessed the strength parameters and compared the profit percentages after replacement with waste materials Quarry dust can be replaced by 20% and beyond that the difference in strength is not much

  • An Experimental Study on Replacement of Fine Aggregate

    An Experimental Study on Replacement of Fine Aggregate with Quarry Dust The rapid growth in development of construction industry is leading to an increase in utilization of natural resources like river sand due to which there has been a much scarcity in availability for construction

  • Partial Replacement of Sand by Quarry Dust in Concrete

    International Journal of Scientific and Research Publications, Volume 5, Issue 7, July 2015 1 ISSN 22503153 Partial Replacement of Sand by Quarry Dust in Concrete Sumit L Chauhan, Raju ABondre Assistant Professor P I G C E Nagpur Abstract The paper describe the role of quarry dust In the of various complex silicates are formed, causing the mass to construction of buildings and other

  • QUARRY DUST FINE POWDER AS SUBSTITUTE FOR FINE

    QUARRY DUST FINE POWDER AS SUBSTITUTE FOR FINE AGGREGATES IN CONCRETE MIX Author: Syed Afzal Basha Subject: International Journal of Scientific Engineering Research Volume 7, Issue 3, March2016 Created Date: 3/25/2016 10:39:13 PM

  • Partial Replacement of Sand by Quarry Dust in Concrete

    investigated the partial replacement of sand with quarry dust Initially cement concrete cube was studied with various proportions of cement concrete + quarry dust (M 20, AND M25) The experimental results showed that the addition of quarry dust as fine aggregate ratio of 30%, 40% and 50% was found to enhance the compressive properties

  • PARTIAL REPLACEMENT OF CEMENT BY QUARRY DUST

    corrosion resistance behavior of inhibitors in concrete containing quarry dust as fine aggregate,” Journal of Engineering and Applied Sciences, vol 6, no 11, pp 124–135, 2011 [12] R P Nanda, A K Das, and N Moharana, “Stone crusher dust as a fine aggregate in concrete for paving

  • EFFECT OF FLY ASH AND QUARRY DUST AS A PARTIAL

    to study the effect of partial replacement of fine aggregates by quarry dust and cement by fly ash on cement concrete 12 NEED FOR INVESTIGATION Quarry Dust These residues are generally less than 1% aggregate production in the normal concrete The introduction of quarry dust for mixing is limited due to its high fineness

  • Partial Replacement of Sand by Quarry Dust in Concrete

    International Journal of Scientific and Research Publications, Volume 5, Issue 7, July 2015 1 ISSN 22503153 Partial Replacement of Sand by Quarry Dust in Concrete Sumit L Chauhan, Raju ABondre Assistant Professor P I G C E Nagpur Abstract The paper describe the role of quarry dust In the of various complex silicates are formed, causing the mass to construction of buildings and other

  • The Utilization of Quarry Dust as Fine Aggregates in

    quarry dust, which is a waste product from quarry, as fine aggregates in traditional concrete During the tenure of the study, some physical and engineering properties of quarry dust and sand were determined and compared The compressive strength of concrete was determined after replacing sand with quarry dust in various ratios

  • Stone Dust in Concrete: Effect on Compressive Strength

    International Journal of Engineering and Technical Research (IJETR) Quarry dust can be utilized in concrete mixtures as a good substitute for natural river sand giving higher strength at 50% replacement (Balamurgan et al, 2013) While using crushed stone dust as fine aggregate in concrete

  • Replacement of Fine Aggregate by using Recyclable

    Various industrial waste materials like quarry dust, glass powder, ceramic dust and coal dust are used as partial replacement of fine aggregate and assessed the strength parameters and compared the profit percentages after replacement with waste materials Quarry dust can be replaced by 20% and beyond that the difference in strength is not much

  • Replacement of stone Dust and Ceramic scrap as Aggregate

    Replacement of stone Dust and Ceramic scrap as Aggregate in Concrete Kiran Niveditha Dept of Civil Engineering, CIT, Gubbi, Tumkur, India *** Natural coarse aggregate in concrete can be replace with ceramic waste aggregate as its properties are well within the range of specifications

  • [PDF] Utilization of Quarry Dust in Cement Concrete Paver

    “Strength and durability properties of concrete containing quarry rock dust as fine aggregate” Natural river sand, if replaced by hundred percent Quarry Rock Dust from quarries, may sometimes give equal or better than the reference concrete made with Natural Sand, in

  • Experimental Investigation on Quarry Dust and Recycled

    Experimental Investigation on Quarry Dust and Recycled Aggregates in Concrete 3 22 Fine Aggregate and Quarry Dust Good Quality River sand, free from silt other impurities were used in this study Sand passing through 475 mm has to be used in this experimental work Quarry dusts are occupied in rest of Thiruvakarai Quarry

  • An Experimental Study on Replacement of Fine Aggregate

    An Experimental Study on Replacement of Fine Aggregate with Quarry Dust The rapid growth in development of construction industry is leading to an increase in utilization of natural resources like river sand due to which there has been a much scarcity in availability for construction

  • Studies on Fresh and Hardened Properties of

    May 01, 2014  Twelve series of mixtures comprising reference concrete with natural aggregate and 100 recycled concrete aggregate with natural fine aggregate replaced with quarry dust ranging from 10 to 100% were prepared for this study All these mixtures were designed for M30 grade (fc′ = 24 MPa [3480 psi]) of concrete

  • Improved Concrete Properties Using Quarry Dust as

    Apr 09, 2015  Strength and durability properties of concrete containing quarry dust as fine aggregate, RIlangovana, NMahendrana and KNagamanib, PgNo 20 to 26, ARPN Journal

  • QUARRY DUST FINE POWDER AS SUBSTITUTE FOR FINE

    QUARRY DUST FINE POWDER AS SUBSTITUTE FOR FINE AGGREGATES IN CONCRETE MIX Author: Syed Afzal Basha Subject: International Journal of Scientific Engineering Research Volume 7, Issue 3, March2016 Created Date: 3/25/2016 10:39:13 PM

  • Stone Dust in Concrete: Effect on Compressive Strength

    International Journal of Engineering and Technical Research (IJETR) Quarry dust can be utilized in concrete mixtures as a good substitute for natural river sand giving higher strength at 50% replacement (Balamurgan et al, 2013) While using crushed stone dust as fine aggregate in concrete

  • Experimental Investigation on Quarry Dust and Recycled

    Experimental Investigation on Quarry Dust and Recycled Aggregates in Concrete 3 22 Fine Aggregate and Quarry Dust Good Quality River sand, free from silt other impurities were used in this study Sand passing through 475 mm has to be used in this experimental work Quarry dusts are occupied in rest of Thiruvakarai Quarry

  • The Utilization of Quarry Dust as Fine Aggregates in

    quarry dust, which is a waste product from quarry, as fine aggregates in traditional concrete During the tenure of the study, some physical and engineering properties of quarry dust and sand were determined and compared The compressive strength of concrete was determined after replacing sand with quarry dust in various ratios

  • International Journal of ChemTech Research

    Hence an attempt has been made to study the characteristic properties of concrete block with partial replacement of fine aggregate by quarry dust and Paddy husk with replacement percentage of 10%, 20%, 30%, 40% and 50% Mix design has been developed for M20 grade concrete design approach using IS for both conventional concrete and concrete with

  • Stone crusher dust as a fine aggregate in Concrete for

    of rock flour as fine aggregate instead of river sand Ilangovana et al, 2008 reported strength of quarry rock dust concrete was comparably 1012 % more than that of similar mix of conventional concrete Hameed and Sekar, 2009 studied effect of crushed stone dust as fine sand and found the

  • Experimental Study of Partial Replacement of Fine

    fine aggregate replaced concrete are compared and the results are tabulated Machine crushed granite obtained from a local quarry was used as coarse aggregate The properties of the coarse ultrasonic pulse velocity and permeability of concrete”, International journal of construction and building materials Vol26, PP416422 [3] IS

  • Studies on Fresh and Hardened Properties of

    May 01, 2014  Twelve series of mixtures comprising reference concrete with natural aggregate and 100 recycled concrete aggregate with natural fine aggregate replaced with quarry dust ranging from 10 to 100% were prepared for this study All these mixtures were designed for M30 grade (fc′ = 24 MPa [3480 psi]) of concrete

  • [PDF] Utilization of Quarry Dust in Cement Concrete Paver

    “Strength and durability properties of concrete containing quarry rock dust as fine aggregate” Natural river sand, if replaced by hundred percent Quarry Rock Dust from quarries, may sometimes give equal or better than the reference concrete made with Natural Sand, in

  • Strength and durability properties of quarry dust powder

    Quarry dust powder is the waste generated from Manufactured Sand (M Sand) units and constitutes to 30–40% of the total quarry dust produced When dry, it turns into fine dust that causes severe health issues to people and also causes serious threats to environment by polluting soil and water

  • International Journal of Civil Engineering and Technology

    of Concrete Containing Quarry Rock Dust as Fine Aggregate, ARPN Journal of Engineering and Applied Sciences, Vol 3(5), pp2026 [2] Galetakis M, Raka S (2004), Utilization of limestone dust for artificial stone production: an experimental approach Miner Eng, 17:355–357

  • Studies on Fresh and Hardened Properties of Recycled

    Twelve series of mixtures comprising reference concrete with natural aggregate and 100% recycled concrete aggregate with natural fine aggregate replaced with quarry dust ranging from 10 to 100% were prepared for this study All these mixtures were designed for M30 grade (fc' = 24 MPa [3480 psi]) of concrete

  • A Study on Strength of Concrete With Partial Replacement

    Considerable decrease in compressive strength was observed from 25% cement replaced with quarry dust References [1] Aiswarya S, Prince Arulraj G, Dilip C in 2013 examined a review on use of metakaolin in concrete IRACST – Engineering Science and Technology: An International Journal (ESTIJ), ISSN: 22503498, Vol3, No3, June 2013

  • An Experimental Investigation on Properties of Concrete by

    cement with GGBS and Fine aggregate with Quarry Dust for application in structural concrete, which will give better understanding on the properties of concrete The effect of GGBS and Quarry Dust (QD) on the properties of Concrete are studied 3 Experimental Programme 31 Properties of